Preliminary research on size measurement of supercooled large droplet in icing wind tunnel

CHEN Shuyue; GUO Xiangdong; WANG Zixu; LIU senyun; WU Yingchun

doi:10.11729/syltlx20200104

Volume 35 Issue 3

Jun. 2021

Turn off MathJax

Article Contents

Article Navigation > Journal of Experiments in Fluid Mechanics > 2021 > 35(3): 22-29

CHEN Shuyue, GUO Xiangdong, WANG Zixu, et al. Preliminary research on size measurement of supercooled large droplet in icing wind tunnel[J]. Journal of Experiments in Fluid Mechanics, 2021, 35(3): 22-29. doi: 10.11729/syltlx20200104

Citation:

PDF( 7400 KB)

Preliminary research on size measurement of supercooled large droplet in icing wind tunnel

doi: 10.11729/syltlx20200104

1.
Key Laboratory of Icing and Anti/De-icing, China Aerodynamics Research and Development Center, Mianyang Sichuan 621000, China
2.
State Key Laboratory of Clean Energy Utilization, Zhejiang University, Hangzhou Zhejiang 310027, China

Received Date: 2020-09-03
Rev Recd Date: 2020-10-13
Publish Date: 2021-06-25

Abstract

Abstract

Drop-size measurement of the supercooled large droplet (SLD) is very important for capacity building of the icing wind tunnel. In order to evaluate the capability of Phase Doppler Interferometer Flight Probe Dual Range (PDI-FPDR) in measuring the diameter of SLD, the standard droplet stream generated by a droplet generator, was used to evaluate the uncertainty of PDI-FPDR for drop size measurement. Then, for the real large-droplet spray, the particle size characteristic parameters were measured by Malvern and PDI-FPDR simultaneously. The large-droplet spray measurement capability of PDI-FPDR has been further evaluated. The results show that the small size range channel of PDI-FPDR can't accurately measure large droplets, and its measurement results are much smaller than the real droplet size. The relative error of measuring a 189.0 μm droplet is -72.8%. The measuring accuracy of the large size range channel is high, but the precision is poor. The relative error of measuring a 240.5 μm droplet is -5.1%, and the maximum deviation is 50.2 μm. For typical large-droplet spray, the PDI-FPDR small size range channel has poor applicability under measuring conditions of median volume diameter (MVD) greater than 75.0 μm. The measured MVD values of PDI-FPDR large size range channel are larger than those of Malvern.
- icing wind tunnel,
- supercooled large droplet,
- droplet size,
- droplet flow,
- spray

FullText(HTML)

References(25)

References

[1]	CEBECI T, KAFYEKE F. Aircraft icing[J]. Annual Review of Fluid Mechanics, 2003, 35(1): 11-21. doi: 10.1146/annurev.fluid.35.101101.161217
[2]	林贵平, 卜雪琴, 申晓斌, 等. 飞机结冰与防冰技术[M]. 北京: 北京航空航天大学出版社, 2016.
[3]	Federal Aviation Administration (FAA), DOT. FAA-2010-0636, Airplane and engine certification requirements in supercooled large drop, mixed phase, and ice crystal icing conditions[S]. Washington, DC: Federal Register, 2014.
[4]	符澄, 宋文萍, 彭强, 等. 结冰风洞过冷大水滴结冰条件模拟能力综述[J]. 实验流体力学, 2017, 31(4): 1-7. doi: 10.11729/syltlx20160118 FU C, SONG W P, PENG Q, et al. An overview of supercooled large droplets icing condition simulation capability in icing wind tunnels[J]. Journal of Experiments in Fluid Mechanics, 2017, 31(4): 1-7. doi: 10.11729/syltlx20160118
[5]	FERSCHITZ H, WANNEMACHER M, BUCEK O, et al. Development of SLD capabilities in the RTA icing wind tunnel[J]. SAE International Journal of Aerospace, 2017, 10(1): 12-21. doi: 10.4271/2017-01-9001.
[6]	IDE R F, OLDENBURG J R. Icing cloud calibration of the NASA Glenn icing research tunnel[R]. AIAA-2001-0234, 2001. doi: 10.2514/6.2001-234
[7]	IDE R F, SHELDON D W. 2006 icing cloud calibration of the NASA Glenn icing research tunnel[R]. NASA/TM-2008-215177, 2008.
[8]	VAN ZANTE J F, IDE R F, STEEN L E. NASA Glenn icing research tunnel: 2012 cloud calibration procedure and results[C]//Proc of the 4th AIAA Atmospheric and Space Environments Conference. 2012. doi: 10.2514/6.2012-2933
[9]	VAN ZANTE J F, IDE R F, STEEN L E. NASA Glenn icing research tunnel: 2014 cloud calibration procedures and results[R]. NASA/TM-2014-218392, 2014.
[10]	STEEN L E, IDE R F, VAN ZANTE J F, et al. NASA Glenn icing research tunnel: 2014 and 2015 cloud calibration procedures and results[R]. NASA/TM-2015-218758, 2015.
[11]	IMPERATO L, LEONE G, VECCHIONE L. Spray nozzles experiment comparison in laboratory and icing wind tunnel testing[R]. AIAA-2000-0487, 2000. doi: 10.2514/6.2000-487
[12]	ORCHARD D M, CLARK C, OLESKIW M. Development of a supercooled large droplet environment within the NRC altitude icing wind tunnel[C]//Proc of the SAE 2015 International Conference on Icing of Aircraft, Engines, and Structures. 2015. doi: 10.4271/2015-01-2092
[13]	Society of Automotive Engineers. SAE ARP-4906, Droplet sizing instrumentation used in icing facilities[S]. Warrendale, PA: SAE International, 2007. doi: 10.4271/AIR4906
[14]	Society of Automotive Engineers. SAE ARP-5666, Icing wind tunnel interfacility comparison tests[S]. Warrendale, PA: SAE International, 2012. doi: 10.4271/AIR5666A
[15]	LEONE G, VECCHIONE L, DE MATTEIS P, et al. The new CIRA icing wind tunnel spray bar system development[C]//Proc of the 38th Aerospace Sciences Meeting and Exhibit. 2000. doi: 10.2514/6.2000-629
[16]	程尧, 张平涛, 郭向东, 等. 机载式相位多普勒干涉仪在结冰风洞的应用[J]. 兵工自动化, 2017, 36(9): 55-57. https://www.cnki.com.cn/Article/CJFDTOTAL-BGZD201709014.htm CHENG Y, ZHANG P T, GUO X D, et al. Application of PDI-FPDR in icing wind tunnel[J]. Ordnance Industry Automation, 2017, 36(9): 55-57. https://www.cnki.com.cn/Article/CJFDTOTAL-BGZD201709014.htm
[17]	王梓旭, 沈浩, 郭龙, 等. 3 m×2 m结冰风洞云雾参数校测方法[J]. 实验流体力学, 2018, 32(2): 61-67. doi: 10.11729/syltlx20170163 WANG Z X, SHEN H, GUO L, et al. Cloud calibration method of 3 m×2 m icing wind tunnel[J]. Journal of Experiments in Fluid Mechanics, 2018, 32(2): 61-67. doi: 10.11729/syltlx20170163
[18]	郭向东, 张平涛, 赵照, 等. 大型结冰风洞云雾场适航应用符合性验证[J]. 航空学报, 2020, 41(10): 123879. doi: 10.7527/S1000-6893.2020.23879 GUO X D, ZHANG P T, ZHAO Z, et al. Airworthiness application compliance verification of cloud flowfield in large icing wind tunnel[J]. Acta Aeronautica et Astronautica Sinica, 2020, 41(10): 123879. doi: 10.7527/S1000-6893.2020.23879
[19]	Artium Technologies Inc. PDI flight probe dual range (FPDR) user manual[Z]. Artium Technologies Inc, 2013.
[20]	BACHALO W D. Measurement techniques for turbulent two-phase flow research[C]//Proc of International Symposium on Multiphase Fluid, Non-Newtonian Fluid and Physicochemical Fluid Flows. 1997.
[21]	STRAPP J W, OLDENBURG J, IDE R, et al. Wind tunnel measurements of the response of hot-wire liquid water content instruments to large droplets[J]. Journal of Atmospheric and Oceanic Technology, 2003, 20(6): 791-806. doi:10.1175/1520-0426(2003)020<0791:wtmotr>2.0.co;2
[22]	WU X C, LYU Q M, WU Y C, et al. Dual-stream of monodisperse droplet generator[J]. Chemical Engineering Science, 2020, 223: 115645. doi: 10.1016/j.ces.2020.115645
[23]	Malvern Instruments Ltd. Spraytec user manual[Z]. Malvern Instruments Ltd, 2006.
[24]	易贤, 郭龙, 符澄, 等. 结冰风洞试验段水滴分布特性分析[J]. 实验流体力学, 2016, 30(3): 2-7. doi: 10.11729/syltlx20160034 YI X, GUO L, FU C, et al. Analysis of water droplets distribution in the test section of an icing wind tunnel[J]. Journal of Experiments in Fluid Mechanics, 2016, 30(3): 2-7. doi: 10.11729/syltlx20160034
[25]	李维浩, 易贤, 李伟斌, 等. 过冷大水滴变形与破碎的影响因素[J]. 航空学报, 2018, 39(12): 122243. doi: 10.7527/S1000-6893.2018.22243 LI W H, YI X, LI W B, et al. Influence factors on deformation and breakup of supercooled large droplets[J]. Acta Aeronautica et Astronautica Sinica, 2018, 39(12): 122243. doi: 10.7527/S1000-6893.2018.22243