The experimental investigation on full-scale dynamic separation for an inlet shroud

Zhu Guoxiang; Wang Lei; Yuan Chaokai; Wang Chun

doi:10.11729/syltlx20180176

Volume 33 Issue 4

Turn off MathJax

Article Contents

Article Navigation > Journal of Experiments in Fluid Mechanics > 2019 > 33(4): 45-51

Zhu Guoxiang, Wang Lei, Yuan Chaokai, et al. The experimental investigation on full-scale dynamic separation for an inlet shroud[J]. Journal of Experiments in Fluid Mechanics, 2019, 33(4): 45-51. doi: 10.11729/syltlx20180176

Citation:

PDF( 2655 KB)

The experimental investigation on full-scale dynamic separation for an inlet shroud

doi: 10.11729/syltlx20180176

1.
Beijing Aerospace Technology Institute, Beijing 100074, China
2.
State Key Laboratory of High-Temperature Gas Dynamics, Institute of Mechanics, Chinese Academy of Sciences, Beijing 100190, China

Received Date: 2018-11-13
Rev Recd Date: 2019-03-02
Publish Date: 2019-08-25

Abstract

Abstract

The inlet shroud is widely used in high-speed vehicles since it can avoid unstart phenomenon under the low Mach number flight condition. As the separation process directly determines the safety of the flight vehicle, it is necessary to testify the separation process in the ground testing. In this paper, the advantage of the JF-12 shock wind tunnel is utilized fully to develop the high-speed separation testing technique. The similarity criterion which is suitable for the high-speed separation is deduced for three testing purposes. The observation and identification methods are developed for the high speed separation trace. A set of the high-precision sequence control system is built. Some protection measures are adopted to avoid the risk from the high speed shroud. Using these techniques, a typical 2-dimensional forebody/inlet with the shroud was used for the separation testing in JF-12. The separation trace under the freestream condition of dynamic pressure 100kPa is obtained successfully by the testing freestream of dynamic pressure 50kPa.
- dynamic separation,
- inlet shroud,
- similarity criterion,
- shock tunnel,
- trace observation

FullText(HTML)

References(16)

References

[1]	Walker S H, Rodgers F C, Esposita A L. Hypersonic Collaborative Australia/United States Experiment (HyCAUSE)[R]. AIAA-2005-3254, 2005.
[2]	Gruber M R, Jackson K, Liu J W. Hydrocarbon-fueled scramjet combustor flowpath development for Mach 6-8 HIFiRE flight experiments[R]. AFRL-RZ-WP-TP-2010-2243, 2008.
[3]	Brase L O, Haudrich D P. Flutter and divergence assessment of the HyFly missile[R]. AIAA-2009-2462, 2009.
[4]	Hass N E, Smart M K, Paull A. Flight data analysis of HyShot 2[C]//Proc of AIAA/CIRA 13th International Space Planes and Hypersonic Systems and Technologies Conference. 2005.
[5]	徐敏, 刘振.基于多块嵌套结构动网格的拦截弹防热保护罩的二维分离模拟[J].计算力学学报, 2007, 24(3):375-378. doi: 10.3969/j.issn.1007-4708.2007.03.023 Xu M, Liu Z. Two-dimensional simulations about the separa-tion of the interceptor missile shroud covers based on moving multi-block chimera structure grids[J]. Chinese Journal of Computational Mechanics, 2007, 24(3):375-378. doi: 10.3969/j.issn.1007-4708.2007.03.023
[6]	Cavallo P A, Dash S M. Aerodynamics of multi-body separation using adaptive unstructured grids[R]. AIAA-2000-3949, 2000.
[7]	Wang S Y, Li C, Chen W. Numerical investigation on unsteady flows with an air-breathing hypersonic vehicle during its shroud separation[R]. AIAA-2017-2335, 2017.
[8]	Buning P G, Wong T C, Dilley A D, et al. Prediction of Hyper-X stage separation aerodynamics using CFD[R]. AIAA-2000-4009, 2000.
[9]	王元靖, 吴继飞, 陶洋, 等.高超声速多体干扰与分离试验[J].航空动力学报, 2010, 25(4):902-906. http://d.old.wanfangdata.com.cn/Periodical/ltlxsyycl201003021 Wang Y J, Wu J F, Tao Y, et al. Hypersonic experimental investigation on interference and stage separation of a multi-body system[J]. Journal of Aerospace Power, 2010, 25(4):902-906. http://d.old.wanfangdata.com.cn/Periodical/ltlxsyycl201003021
[10]	赵忠良, 龙尧松, 余立, 等.高超声速风洞子母弹分离干扰测力试验技术[J].流体力学试验与测量, 2004, 18(3):32-35. http://d.old.wanfangdata.com.cn/Periodical/ltlxsyycl200403007 Zhao Z L, Long Y S, Yu L, et al. Hypersonic wind tunnel interference force test of sub-munition reentry separation[J]. Experiments and Measurements in Fluid Mechanics, 2004, 18(3):32-35. http://d.old.wanfangdata.com.cn/Periodical/ltlxsyycl200403007
[11]	Resch L R, Hedlund E R, Decesaris C A. Hypersonic shroud separation testing at the naval surface warfare center hyper-velocity wind tunnel 9[R]. AIAA-92-2757, 1992.
[12]	Resch L, Decesaris C, Hedlund E R. The naval surface warfare center hypervelocity wind tunnel 9 hypersonic shroud separation testing capability[R]. AIAA-92-0676, 1992.
[13]	Holden M S, Harvey J, MacLean M, et al. Development and application of a new ground test capability to conduct full-scale shroud and stage separation studies at duplicated flight conditions[R]. AIAA-2005-696, 2005.
[14]	姜宗林, 李进平, 赵伟, 等.长试验时间爆轰驱动激波风洞技术研究[J].力学学报, 2012, 44(5):824-831. http://d.old.wanfangdata.com.cn/Conference/7714651 Jiang Z L, Li J P, Zhao W, et al. Investigation into techniques for extending the test-duration of detonation-driven shock tunnels[J]. Chinese Journal of Theoretical and Applied Mechanics, 2012, 44(5):824-831. http://d.old.wanfangdata.com.cn/Conference/7714651
[15]	恽起麟.风洞实验[M].北京:国防工业出版社, 2000. Yun Q L. Handbook of wind tunnel test[M]. Beijing:National Defense Industry Press, 2000.
[16]	李周复.风洞特种实验技术[M].北京:航空工业出版社, 2010. Li Z F. Special experimental techniques in wind tunnels[M]. Beijing:Aviation Industry Press, 2010