Hypersonic wind tunnel drop-model test on cover ejection from cargo projectile at large angle of attack

Jiang Zenghui; Song Wei; Chen Nong; Jia Quyao

doi:10.11729/syltlx20160020

Volume 30 Issue 5

Turn off MathJax

Article Contents

Article Navigation > Journal of Experiments in Fluid Mechanics > 2016 > 30(5): 42-48

Jiang Zenghui, Song Wei, Chen Nong, et al. Hypersonic wind tunnel drop-model test on cover ejection from cargo projectile at large angle of attack[J]. Journal of Experiments in Fluid Mechanics, 2016, 30(5): 42-48. doi: 10.11729/syltlx20160020

Citation:

PDF( 4152 KB)

Hypersonic wind tunnel drop-model test on cover ejection from cargo projectile at large angle of attack

doi: 10.11729/syltlx20160020

China Academy of Aerospace Aerodynamics, Beijing 100074, China

Received Date: 2016-01-22
Rev Recd Date: 2016-05-27
Publish Date: 2016-10-25

Abstract

Abstract

Hypersonic wind tunnel drop-model tests were conducted at Mach 5 to investigate the separation characteristics of cover ejection from cargo projectile at large angle of attack(25°). In the test, the whole separation process was observed. The motion trajectory and displacement curves of the covers in the separation process are analyzed. The comparison of the separation characteristics is made between the covers on the windward side and the leeward side. The motion trajectory of the covers is quite different between the windward side and the leeward side, but both motion trajectories of the covers on the two sides can be divided into two stages. For the covers on the windward side, the displacement of y orientation is dominant at stage Ⅰ, while x orientation becomes dominant at stage Ⅱ. For the covers on the leeward side, the displacements are approximately equivalent for x and y orientation at stage Ⅰ, while x orientation becomes dominant at stage Ⅱ.The x orientation displacements for covers on both sides can be evidently divided into two stages. At stage Ⅰ, the displacements change slowly, while those increase rapidly at stage Ⅱ. The y orientation displacements for covers on both sides have no obvious stage transition, but the y orientation velocity on the windward side is larger than that on the leeward side. Similar to x orientation displacements, the total displacements for covers on both sides can also be divided into two stages, and they also change slowly at stage Ⅰ, and then increase rapidly at stage Ⅱ.
- multi-body separation,
- wind tunnel drop-model test,
- cover ejection from cargo projectile,
- large angle of attack,
- hypersonic

FullText(HTML)

References(29)

References

[1]	杨启仁.子母弹飞行动力学[M].北京:国防工业出版社, 1999:1-16. Yang Q R. Flight dynamics of cargo projectile[M]. Beijing:National Defense Industry Press, 1999:1-16.
[2]	王巍, 刘君, 郭正.子母弹抛壳过程非定常流动的数值模拟[J].空气动力学学报, 2006, 24(3):285-288. http://www.cnki.com.cn/Article/CJFDTOTAL-KQDX200603002.htm Wang W, Liu J, Gou Z. Numerical simulation of release the cover from cargo projectile[J]. Acta Aerodynamica Sinica, 2006, 24(3):285-288. http://www.cnki.com.cn/Article/CJFDTOTAL-KQDX200603002.htm
[3]	柳森, 张鲁民.再入弹抛壳气动特性研究[J].空气动力学学报, 1993, 11(1):16-21. http://www.cnki.com.cn/Article/CJFDTOTAL-KQDX199301002.htm Liu S, Zhang L M. Numerical investigation of flow over shrapel/shell discarding configuration[J]. Acta Aerodynamica Sinica, 1993, 11(1):16-21. http://www.cnki.com.cn/Article/CJFDTOTAL-KQDX199301002.htm
[4]	梁京春.导弹抛壳问题的分析[J].气动实验与测量控制, 1989, 3(3):81-87. http://www.cnki.com.cn/Article/CJFDTOTAL-LTLC198903012.htm Liang J C. Analysis on sabot-discard from missiles[J]. Aerodynamic Experiment and Measurement & Control, 1989, 3(3):81-87. http://www.cnki.com.cn/Article/CJFDTOTAL-LTLC198903012.htm
[5]	龙尧松, 涂正光, 李亨鹤, 等.高超音速导弹壳片分离的CFD计算研究[C].第十二届全国计算流体力学会议, 2004, 3:386-390. Long Y S, Tu Z G, Li H H, et al. Research on shell separation of hypersonic missile by CFD method[C]. The Twelfth National Conference on Computational Fluid Dynamics, 2004, 3:386-390.
[6]	龙尧松, 涂正光.导弹壳片分离的计算与试验研究[C].首届全国航空航天领域中的力学问题学术研讨会, 2004:124-127. Long Y S, Tu Z G. Simulation and experimental research on shell separation of missiles[C]. The First National Conference on Mechanics Problems in Aeronautics and Space Field, 2004:124-127.
[7]	杨永健, 张来平, 高树椿, 等.多体干扰气动特性数值模拟方法研究[C].第十一届全国计算流体力学会议, 2002:325-330. Yang Y J, Zhang L P, Gao S C, et al. Research on numerical method of multi-body interference aerodynamic characteristic[C]. The Eleventh National Conference on Computational Fluid Dynamics, 2002:325-330.
[8]	黄蓓, 王浩, 王帅, 等.薄片状体沉降过程中的多体干扰流场特性[J].弹道学报, 2012, 24(1):41-46. http://www.cnki.com.cn/Article/CJFDTOTAL-DDXB201201010.htm Huang B, Wang H, Wang S, et al. Flow field characteristics of multi-plates interference in descent[J]. Journal of Ballistics, 2012, 24(1):41-46. http://www.cnki.com.cn/Article/CJFDTOTAL-DDXB201201010.htm
[9]	王巍.有相对运动的多体分离过程非定常数值算法研究及实验验证[D].长沙:国防科学技术大学, 2008. Wang W. Numerical simulation technique research and experiment verification for unsteady multi-body flowfield involving relative movement[D]. Changsha:National University of Defense Technology, 2008.
[10]	马家驩, 唐宗衡, 张小平, 等.抛壳方案的模型自由飞试验[R].中国科学院力学研究所报告, 1983. Ma J H, Tang Z H, Zhang X P, et al. Wind tunnel free-flight test on shell separation[R]. IMCAS Report, 1983.
[11]	李周复.风洞特种试验技术[M].北京:航空工业出版社, 2010:88-161.Li Z F. Wind tunnel special tests technique[M]. Beijing:Aviation Industry Press, 2010:88-161.
[12]	陈少松, 丁则胜.旋转子母弹后抛撒风洞试验研究[J].流体力学实验与测量, 2004, 18(2):43-46. http://www.cnki.com.cn/Article/CJFDTOTAL-LTLC200402010.htm Chen S S, Ding Z S. The wind tunnel experiment techniques of backward dispersion of turning shrapnel[J]. Experiments and Measurements in Fluid Mechanics, 2004, 18(2):43-46. http://www.cnki.com.cn/Article/CJFDTOTAL-LTLC200402010.htm
[13]	孙新利, 蔡星会, 王少龙, 等.子母弹静态开舱抛射实验[J].兵工学报, 2002, 23(2):258-260. http://www.cnki.com.cn/Article/CJFDTOTAL-BIGO200202028.htm Sun X L, Cai X H, Wang S L, et al. Projectile tests from a bomb dispenser[J]. Acta Armamentarii, 2002, 23(2):258-260. http://www.cnki.com.cn/Article/CJFDTOTAL-BIGO200202028.htm
[14]	程仁全, 于夕民. NH-1风洞外挂物高速投放实验技术[R].南京航空航天大学科技报告, 1984, NHJB-85-2359. Cheng R Q, Yu X M. Experimental technique about dropping test of external stores in the NH-1 high speed wind tunnel[R]. Nanjing University of Aeronautics & Astronautics Report, NHJB-85-2359, 1984.
[15]	张竹坡.高速风洞自由投放实验[R].中国空气动力研究与发展中心科技报告, 1983. Zhang Z P. Dropping test in the high speed wind tunnel[R]. China Aerodynamics Research and Development Centre Report, 1983.
[16]	Hinson W F. Transonic and supersonic ejection release characteristics of six dynamically scaled external-store shapes from an 0.086-scale model of a current fighter airplane[R]. Langley Research Center, NASA-TM-X-12865N26632, 1959.
[17]	Black R L. High-speed store separation-correlation between wind-tunnel and flight-test data[J]. Journal of Aircraft, 1969, 6(1):42-45. doi: 10.2514/3.43999
[18]	Clark R L. Evaluation of F-111 weapon bay aero-acoustic and weapon separation improvement techniques[R]. Air Force Flight Dynamics Lab, AFFDL-TR-79-3003(ADA070253), 1979.
[19]	Allee E G. Store separation testing techniques at the Arnold Engineering Development Center:Volume IV:description of dynamic drop store separation testing[R]. Arnold Engineering Development Center, AEDC-TR-79-1(ADA087490), 1980.
[20]	Arterbury R L, Morgret C H, Keen K S. An analytic investigation of accuracy requirements for onboard instrumentation and film data for dynamically scaled wind tunnel drop models[R]. Arnold Engineering Development Center, AEDC-TR-96-7(ADA322893), 1997.
[21]	Shalaev V I, Fedorov A V. Dynamics of slender bodies separating from rectangular cavities[C]. AIAA-2001-2996.
[22]	Schwartz D R, Bower W W, Kibens V. Active flow control for high-speed weapon release from a bay[R]. Air Force Research Lab Air Vehicles Directorate Wright-Patterson AFB, OH, RTO-MP-AVT-108-30(ADA468798), 2004.
[23]	Johnson R A, Stanek M J, Grove J E. Store separation trajectory deviations due to unsteady weapons bay aerodynamics[C]. AIAA-2008-188.
[24]	Paul M C. Experimental measurements of store separation using dry ice models in a subsonic flow[R]. Air Force Institute of Technology, AFIT/GAE/ENY/11-M23(ADA540224), 2011.
[25]	Flora T J, Reeder M F, Lofthouse A, et al. Dynamic store release of ice models from a cavity into Mach 2.9 flow[J]. Journal of Aircraft, 2014, 51(6):1927-1941.
[26]	Holden M S, Harvey J, MacLean M, et al. Development and application of a new ground test capability to conduct full-scale shroud and stage separation studies at duplicated flight conditions[C]. AIAA-2005-696.
[27]	Holden M S, Smolinski G J, Mundy E, et al. Experimental studies for hypersonic vehicle design and code validation of unsteady flow characteristics associated with free flight shroud and stage seperation and mode switching[C]. AIAA-2008-642.
[28]	Henicke B, Yechout T. Aerodynamic investigation of NASA Crew Exploration Vehicle Forward Bay Cover separation characteristics[C]. AIAA-2010-191.
[29]	Montes D R, West T J, Yechout T R. Investigation of Orion Crew Exploration Vehicle Forward Bay Cover separation characteristics[C]. AIAA-2011-1308.