Free oscillation dynamic derivative test technology of a short-blunt shape vehicle
-
摘要: 为研究短钝外形飞行器的动稳定特性,基于自由振动动导数试验方法在1.2 m量级亚跨超声速风洞中建立了动导数测量试验技术。通过新设计的弹性铰链和轴承铰链解决了短钝外形飞行器弹性支撑和低频振动模拟问题。利用新建立的试验装置研究了马赫数、迎角、减缩频率对动稳定特性的影响。在短钝外形飞行器气动力特点下,新设计的弹性铰链能够满足模型支撑和振动需要,轴承铰链的支撑方式可以在风洞中模拟接近实际减缩频率的振动。在亚跨超声速风洞中完成了某短钝外形飞行器俯仰动导数的测量,获取了俯仰动不稳定状态点,为此类飞行器的动稳定特性研究提供了试验基础。Abstract: In order to study the dynamic stability characteristics of the short-blunt shape vehicle, the free oscillation dynamic derivative test method is used to establish the dynamic derivative measurement test technology in the 1.2 m trisonic wind tunnel. The newly designed elastic hinges and bearing hinges solve the problem of elastic support and low-frequency oscillation simulation of the short-blunt shape vehicle, and the newly established test device is used to study the influence of the Mach number, angle of attack, reduced frequency, and shape on dynamic stability characteristics. The newly designed elastic hinge can meet the model support and oscillation requirement under the aerodynamic characteristic condition of the short-blunt shape vehicle in the wind tunnel, and the bearing hinge support can simulate the oscillation frequency close to the actual reduced frequency in the wind tunnel. In the trisonic wind tunnel, the measurement of the pitch derivative of a short-blunt shaped vehicle was completed, and the unstable state points of the pitching were obtained, which provides experimental support for future research on the dynamic stability characteristics of this type of vehicle.
-
表 1 典型的短钝外形模型风洞试验载荷
Table 1. Typical wind tunnel test load of short-blunt shape model
单元 轴向力
X/N法向力
Y/N俯仰力矩
Mz / (N·m)最大载荷 3000 100 6 表 2 不同梁厚度下的刚度、应力、变形角
Table 2. Stiffness, stress and deformation angle under different beam thickness
梁厚度/
mm刚度/
(N·m·rad–1)最大应力/
MPa最大理论变形角/(°) δ 16.06 2317.0 21.69 δ+0.25 30.64 1608.0 11.29 δ+0.50 54.46 1158.0 6.68 δ+0.75 77.48 917.4 4.44 δ+1.00 110.99 650.7 2.92 δ+1.25 221.56 434.4 1.55 表 3 三次重复性试验结果
Table 3. Results of three repeated tests
试验理论迎角 0° 2° 5° 8° 10° Test 1 –0.3936 –0.3355 –0.3936 –0.4126 –0.5197 Test 2 –0.3415 –0.3768 –0.4115 –0.3575 –0.5685 Test 3 –0.3858 –0.3526 –0.3795 –0.3988 –0.5865 均值 –0.3736 –0.3550 –0.3949 –0.3896 –0.5582 标准差 0.0281 0.0208 0.0160 0.0287 0.0346 -
[1] WAY D W, POWELL R W, CHEN A, et al. Mars science laboratory: entry, descent, and landing system performance[C]//Proc of the 2007 IEEE Aerospace Conference. 2007. doi: 10.1109/AERO.2007.352821 [2] REICHENAU D E A. Aerodynamic characteristics of disk-gap-band parachutes in the wake of Viking entry forebodies at Mach numbers from 0.2 to 2.6[R]. AEDC-TR-72-78, 1972. doi: 10.21236/ad0746291 [3] Petrick D, Davis B, Peregino P, et al. An experimental approach to determine the flight dynamics of NASA's Mars Science Lab Capsule[R]. ARL-TR-6790, 2017. [4] EDQUIST K T, HOLLIS B R. Mars science laboratory heatshield aerothermodynamics: design and reconstruction [R]. AIAA 2013-2781, 2013. doi: 10.2514/6.2013-2781 [5] ALKANDRY H, BOYD I, REED E, et al. Numerical study of hypersonic wind tunnel experiments for Mars entry aeroshells[R]. AIAA 2009-3918, 2009. doi: 10.2514/6.2009-3918 [6] YOSHINAGA T,TATE A,WATANABE M,et al. Orbital re-entry experiment vehicle ground and flight dynamic test results comparison[J]. Journal of Spacecraft and Rockets,1996,33(5):635-642. doi: 10.2514/3.26813 [7] 赵梦熊. 载人飞船返回舱的再入气动环境[J]. 气动实验与测量控制,1995,9(4):1-7.ZHAO M X. The aerodynamic and aerothermodynamic circumstances of capsule type re-entry vehicle[J]. Aerodynamic Experiment and Measurement & Control,1995,9(4):1-7. [8] 赵梦熊. 载人飞船返回舱的动稳定性[J]. 气动实验与测量控制,1995,9(2):1-8.ZHAO M X. The dynamic stability characteristics of capsule type Re-entry vehicles[J]. Aerodynamic Experiment and Measurement & Control,1995,9(2):1-8. [9] 方方. 神舟飞船返回舱气动设计综述[J]. 航天器工程,2004,13(1):124-131. doi: 10.2514/3.26813 [10] 马洋,张青斌,丰志伟. 大气环境对火星探测器气动特性影响分析[J]. 航天返回与遥感,2016,37(2):18-25. doi: 10.3969/j.issn.1009-8518.2016.02.003MA Y,ZHANG Q B,FENG Z W. Influence of atmosphere condition on aerodynamic characteristics of Mars probe[J]. Spacecraft Recovery & Remote Sensing,2016,37(2):18-25. doi: 10.3969/j.issn.1009-8518.2016.02.003 [11] 何开锋,和争春. 飞船返回舱跨声速全局稳定性研究[J]. 飞行力学,1999,17(3):34-38. doi: 10.3969/j.issn.1002-0853.1999.03.007HE K F,HE Z C. The global stability analysis of reentry capsule transonic flight[J]. Flight Dynamics,1999,17(3):34-38. doi: 10.3969/j.issn.1002-0853.1999.03.007 [12] 宋玉辉,陈农,秦永明. 亚跨超声速返回舱动稳定特性[J]. 航天返回与遥感,2014,35(2):31-38. doi: 10.3969/j.issn.1009-8518.2014.02.005SONG Y H,CHEN N,QIN Y M. Sub-, trans- and super-sonic dynamic stability characteristics for reentry capsule[J]. Spacecraft Recovery & Remote Sensing,2014,35(2):31-38. doi: 10.3969/j.issn.1009-8518.2014.02.005 [13] 刘伟,赵海洋,杨小亮. 返回舱动态稳定性分析及被动控制方法研究[J]. 中国科学G辑,2010,40(9):1156-1164.LIU W,ZHAO H Y,YANG X L. Analysis of dynamic stability and research of passive control method for capsule[J]. Science in China (Series G),2010,40(9):1156-1164. [14] 张涵信,袁先旭,叶友达,等. 飞船返回舱俯仰振荡的动态稳定性研究[J]. 空气动力学学报,2002,20(3):247-259. doi: 10.3969/j.issn.0258-1825.2002.03.001ZHANG H X,YUAN X X,YE Y D,et al. Research on the dynamic stability of an orbital reentry vehicle in pitching[J]. Acta Aerodynamica Sinica,2002,20(3):247-259. doi: 10.3969/j.issn.0258-1825.2002.03.001 [15] 杨在山. 载人飞船返回舱的气动特性分析与外形设计[J]. 气动实验与测量控制,1996,10(4):12-18.YANG Z S. The configuration and aerodynamic characteristics of manned re-entry capsules[J]. Aerodynamic Experiment and Measurement & Control,1996,10(4):12-18. [16] 贾区耀, 陈农, 杨益农, 等. 返回舱跨声速动稳定特性[C]//近代空气动力学研讨会论文集. 2005: 182-187. [17] 梁杰,李志辉,李齐,等. 返回舱再入跨流域气动及配平特性数值研究[J]. 空气动力学学报,2018,36(5):848-855. doi: 10.7638/kqdlxxb-2018.0128LIANG J,LI Z H,LI Q,et al. Numerical simulation of aerodynamic and trim characteristics across different flow regimes for reentry module[J]. Acta Aerodynamica Sinica,2018,36(5):848-855. doi: 10.7638/kqdlxxb-2018.0128 [18] 宋威,艾邦成,蒋增辉,等. 返回舱跨声速自由飞行的静动稳定性[J]. 实验流体力学,2019,33(4):89-94. doi: 10.11729/syltlx20180083SONG W,AI B C,JIANG Z H,et al. Free flight static and dynamic aerodynamic characteristics for re-entry capsule at transonic speed[J]. Journal of Experiments in Fluid Mechanics,2019,33(4):89-94. doi: 10.11729/syltlx20180083 [19] 周伟江. 返回舱自由振动跨声速非定常流场数值模拟[J]. 空气动力学学报,2000,18(1):46-51. doi: 10.3969/j.issn.0258-1825.2000.01.007ZHOU W J. Numerical simulation of unsteady transonic flow around a free oscillating reentry vehicle[J]. Acta Aerodynamica Sinica,2000,18(1):46-51. doi: 10.3969/j.issn.0258-1825.2000.01.007 [20] 胡静,宋玉辉,陈农,等. 返回舱动稳定特性风洞试验的影响参数[J]. 航天返回与遥感,2013,34(5):14-19. doi: 10.3969/j.issn.1009-8518.2013.05.003HU J,SONG Y H,CHEN N,et al. Study of key parameters for dynamic stability of reentry capsule[J]. Spacecraft Recovery & Remote Sensing,2013,34(5):14-19. doi: 10.3969/j.issn.1009-8518.2013.05.003 [21] 范洁川. 风洞试验手册[M]. 北京: 航空工业出版社, 2002: 430-440. [22] USELTEM B L, WALLACE A R. Damping-in-pitch and drag characteristics of the Viking configuration at Mach numbers from 1.6 through 3[R]. AEDC-TR-72-56, 1972. [23] USELTON B L, SHADOW T O, MANSFIELD A C. Damping in pitch derivatives of 120 and 140 degree blunted cones at Mach numbers of 0.3 through 3[R]. AEDC-TR-70-49, 1972.