Experimental study of aerodynamic damping characteristics of a launch vehicle with boosters in transonic flow
-
摘要: 以某带助推的捆绑式运载火箭模型为研究对象,通过试验研究了该带助推的细长体弹性模型在不同马赫数和迎角下的一阶自由-自由弯曲气动阻尼特性和频率变化特性,并采用振型类似、频率降低的模型研究了减缩频率变化对气动阻尼的影响。试验马赫数范围0.70~1.05,试验迎角范围0°~10°。研究表明:迎角对火箭一阶自由-自由弯曲模态的气动阻尼和频率有影响,但规律并不明显;一阶自由-自由弯曲模态的气动阻尼受马赫数影响,并在马赫数0.90附近出现跨声速凹坑现象;一阶模态频率随马赫数增加呈下降趋势,但下降数值较小;减缩频率对气动阻尼有影响,在马赫数0.70~0.90范围内和马赫数1.00之后,气动阻尼随着减缩频率的增加而降低,在马赫数0.92~0.98范围内,气动阻尼随着减缩频率的增加而增加。Abstract: The aerodynamic-damping and frequency characteristics of a launch vehicle with boosters vibrating in the first free-free bending mode, and the influence of the reduced frequency on aerodynamic damping were experimentally studied in a transonic wind tunnel. The test Mach number ranged from 0.70 to 1.05, and the angle of attack ranged from 0° to 10°. The result shows that for the elastic model with boosters, the aerodynamic damping and modal frequency are affected by the angle of attack while the trend is not obvious. The aerodynamic damping changes with the Mach number. The transonic dip appears near the Mach number of 0.90. The modal frequency of the first mode decreases with the increase of the Mach number. The reduced frequency has some effect on the aerodynamic damping that when Mach number ranged from 0.70 to 0.90 and after 1.00, the aerodynamic damping decreases with the increase of the reduced frequency, while Mach number ranged from 0.92 to 0.98, the aerodynamic damping increases with the increase of the reduced frequency.
-
Key words:
- aerodynamic damping /
- transonic /
- wind tunnel test /
- aeroelasticity /
- reduced frequency
-
表 1 一阶自由-自由弯曲模态参数
Table 1. Structural dynamic properties of the 1st free-free bending mode
Model Modal frequency/Hz Structural damping ratio Basic model 163.4 0.0165 Model "L" 112.8 0.0125 -
[1] 倪嘉敏.我国运载火箭气动设计回顾[C]//近代空气动力学研讨会论文集. 2005.NI J M. Review of aerodynamic design of China's launch vehicle[C]//Proceedings of the Modern Aerodynamics Symposium. 2005. [2] 崔尔杰.流固耦合力学研究与应用进展[C]//钱学森科学贡献暨学术思想研讨会论文集. 2001.CUI E J. Research and application progress of fluid-structure interaction mechanics[C]//Proceedings of Seminar of Qian Xuesen Scientific Contributions and Academic Thoughts. 2001. [3] 程镇煌.宇航飞行器跨音速气动弹性问题探讨[J].上海航天, 1997, (6):16-21. https://www.cnki.com.cn/Article/CJFDTOTAL-SHHT706.003.htmCHENG Z H. Discussion on transonic pneumatic elasticity of spacecraft[J]. Aerospace Shanghai, 1997, (6):16-21. https://www.cnki.com.cn/Article/CJFDTOTAL-SHHT706.003.htm [4] REDING J P, ERICSSON L E. Effect of aeroelastic considerations on seasat-A payload shroud design[J]. Journal of Spacecraft and Rockets, 1981, 18(3):241-247. doi: 10.2514/3.57810 [5] COLE H A. Dynamic response of hammerhead launch vehicles to transonic buffeting[R]. NASA TN D-1982, 1963. [6] BARTELS R E, WIESEMAN C D, MINECK R E. Computational aeroelastic analysis of the ares launch vehicle during ascent[R]. AIAA 2010-4374, 2010. [7] AZEVEDO J L F. Aeroelastic analysis of launch vehicles in transonic flight[J]. Journal of Spacecraft and Rockets, 1989, 26(1):14-23. doi: 10.2514/3.26027 [8] SINCLAIR A J, FLOWERS G T. Low-order aeroelastic model of launch-vehicle dynamics[R]. AIAA 2010-7725, 2010. [9] DOTSON K W. Transient coupling of launch vehicle bending responses with aerodynamic flow state variations[J]. Journal of Spacecraft and Rockets, 2001, 38(1):97-104. doi: 10.2514/2.3660 [10] COLE S R, HENNING T L. Buffet response of a hammerhead launch vehicle wind-tunnel model[J]. Journal of Spacecraft and Rockets, 1992, 29(3):379-385. doi: 10.2514/3.26362 [11] 冯明溪, 王志安.火箭跨音速动导数和抖振实验[J].宇航学报, 1987(1):55-62. https://www.cnki.com.cn/Article/CJFDTOTAL-YHXB198701007.htmFENG M X, WANG Z A. Experiments of transonic derivatives and buffeting of rocket[J]. Journal of Astronautics, 1987(1):55-62. https://www.cnki.com.cn/Article/CJFDTOTAL-YHXB198701007.htm [12] 冉景洪, 刘子强, 胡静, 等.减阻杆气动阻尼研究[J].力学学报, 2014, 46(4):636-641. https://www.cnki.com.cn/Article/CJFDTOTAL-LXXB201404019.htmRAN J H, LIU Z Q, HU J, et al. Research of aero-damping for blunt with spike[J]. Chinese Journal of Theoretical and Applied Mechanics, 2014, 46(4):636-641. https://www.cnki.com.cn/Article/CJFDTOTAL-LXXB201404019.htm [13] 白葵, 冯明溪.弹性模型实验技术[J].流体力学实验与测量, 1999, 13(1):38-42. doi: 10.3969/j.issn.1672-9897.1999.01.006BAI K, FENG M X. Aeroelastic model and the buffet experimental technique[J]. Experiments and Measurements in Fluid Mechanics, 1999, 13(1):38-42. doi: 10.3969/j.issn.1672-9897.1999.01.006 [14] JI C, RAN J H, LI F, et al. The aerodynamic damping test of elastic launch vehicle model in transonic flow[C]//Proc of the 64th International Astronautical Congress. 2013. [15] 季辰, 吴彦森, 何岗, 等.运载火箭气动阻尼风洞试验研究[C]//第十二届全国空气弹性学术交流会论文集. 2011.JI C, WU Y S, HE G, et al. Experimental study on aerodynamic damping wind tunnel of launch vehicle[C]//Proceedings of the 12th National Aeroelasticity Conference. 2011. [16] 季辰, 刘子强, 李锋.钝前缘梯形翼高超声速风洞颤振试验[J].气体物理, 2018, 3(1):54-63. https://www.cnki.com.cn/Article/CJFDTOTAL-QTWL201801008.htmJI C, LIU Z Q, LI F. Hypersonic wind tunnel flutter test for a blunt-leading-edge delta wing[J]. Physics of Gases, 2018, 3(1):54-63. https://www.cnki.com.cn/Article/CJFDTOTAL-QTWL201801008.htm [17] 刘子强, 白葵, 毛国良, 等.锤头体弹性振动跨音速气动阻尼系数的确定[J].宇航学报, 2002, 23(6):1-7. doi: 10.3321/j.issn:1000-1328.2002.06.001LIU Z Q, BAI K, MAO G L, et al. The determination of aerodynamic damping on hammerhead launch vehicles at transonic speeds[J]. Journal of Astronautics, 2002, 23(6):1-7. doi: 10.3321/j.issn:1000-1328.2002.06.001 [18] 朱剑, 冉景洪, 吴彦森, 等.捆绑式运载火箭的气动阻尼数值计算方法[C]//第十三届全国空气弹性学术交流会论文集. 2013.ZHU J, RAN J H, WU Y S, et al. Numerical calculation method for aerodynamic damping of bundle launch vehicles[C]//Proceedings of the 13rd National Aeroelasticity Conference. 2013. [19] JONES G W Jr, FOUGHNER J T Jr. Investigation of buffet pressures on models of large manned launch vehicle configurations[R]. NASA TN D-1633, 1963. [20] CF COE. Surface pressure fluctuations associated with aerodynamic noise[R]. NASA SP-207, 1969. [21] BISPLINGHOFF R L, ASHLEY H, HALFMAN R L. Aeroelasticity[M]. Cambridge:Addison-Wesley Publishing Company Incorporated, 1955. [22] 曹树谦, 张文德, 萧龙翔.振动结构模态分析——理论、实验与应用[M].天津:天津大学出版社, 2014.