The experimental investigation on full-scale dynamic separation for an inlet shroud
-
摘要: 进气道整流罩可以有效避免低马赫数飞行条件下进气道不起动的问题,在高速飞行器中得到广泛使用。整流罩分离过程直接关系到飞行器安全,在地面进行全尺度整流罩分离过程试验验证非常必要。利用JF-12激波风洞设备结构简单、尺度大和动压较高的优势,推导了适用于高速动态分离试验的相似准则,发展了高速分离轨迹观测技术、精确时序控制技术以及必要的风洞防护措施,建立了基于JF-12激波风洞的高速动态全尺度分离试验技术。利用该技术,针对配有进气道整流罩的飞行器前体,以50kPa动压试验条件实现了高动压(100kPa)条件下的动态分离轨迹模拟。Abstract: The inlet shroud is widely used in high-speed vehicles since it can avoid unstart phenomenon under the low Mach number flight condition. As the separation process directly determines the safety of the flight vehicle, it is necessary to testify the separation process in the ground testing. In this paper, the advantage of the JF-12 shock wind tunnel is utilized fully to develop the high-speed separation testing technique. The similarity criterion which is suitable for the high-speed separation is deduced for three testing purposes. The observation and identification methods are developed for the high speed separation trace. A set of the high-precision sequence control system is built. Some protection measures are adopted to avoid the risk from the high speed shroud. Using these techniques, a typical 2-dimensional forebody/inlet with the shroud was used for the separation testing in JF-12. The separation trace under the freestream condition of dynamic pressure 100kPa is obtained successfully by the testing freestream of dynamic pressure 50kPa.
-
Key words:
- dynamic separation /
- inlet shroud /
- similarity criterion /
- shock tunnel /
- trace observation
-
表 1 JF-12激波风洞典型运行参数
Table 1. Typical conditions of shock tunnel JF-12
Ma q/kPa pt/MPa Tt/K p/Pa T/K 5 72.0 3.0 2498 4130 476 6 50.0 4.3 2470 1980 344 表 2 整流罩的质量属性
Table 2. Mass properties of shroud
m/kg Icz/(kg·m2) Ioz/(kg·m2) 模拟条件 20 1.0 5.50 试验条件 10 0.5 2.75 -
[1] Walker S H, Rodgers F C, Esposita A L. Hypersonic Collaborative Australia/United States Experiment (HyCAUSE)[R]. AIAA-2005-3254, 2005. [2] Gruber M R, Jackson K, Liu J W. Hydrocarbon-fueled scramjet combustor flowpath development for Mach 6-8 HIFiRE flight experiments[R]. AFRL-RZ-WP-TP-2010-2243, 2008. [3] Brase L O, Haudrich D P. Flutter and divergence assessment of the HyFly missile[R]. AIAA-2009-2462, 2009. [4] Hass N E, Smart M K, Paull A. Flight data analysis of HyShot 2[C]//Proc of AIAA/CIRA 13th International Space Planes and Hypersonic Systems and Technologies Conference. 2005. [5] 徐敏, 刘振.基于多块嵌套结构动网格的拦截弹防热保护罩的二维分离模拟[J].计算力学学报, 2007, 24(3):375-378. doi: 10.3969/j.issn.1007-4708.2007.03.023Xu M, Liu Z. Two-dimensional simulations about the separa-tion of the interceptor missile shroud covers based on moving multi-block chimera structure grids[J]. Chinese Journal of Computational Mechanics, 2007, 24(3):375-378. doi: 10.3969/j.issn.1007-4708.2007.03.023 [6] Cavallo P A, Dash S M. Aerodynamics of multi-body separation using adaptive unstructured grids[R]. AIAA-2000-3949, 2000. [7] Wang S Y, Li C, Chen W. Numerical investigation on unsteady flows with an air-breathing hypersonic vehicle during its shroud separation[R]. AIAA-2017-2335, 2017. [8] Buning P G, Wong T C, Dilley A D, et al. Prediction of Hyper-X stage separation aerodynamics using CFD[R]. AIAA-2000-4009, 2000. [9] 王元靖, 吴继飞, 陶洋, 等.高超声速多体干扰与分离试验[J].航空动力学报, 2010, 25(4):902-906. http://d.old.wanfangdata.com.cn/Periodical/ltlxsyycl201003021Wang Y J, Wu J F, Tao Y, et al. Hypersonic experimental investigation on interference and stage separation of a multi-body system[J]. Journal of Aerospace Power, 2010, 25(4):902-906. http://d.old.wanfangdata.com.cn/Periodical/ltlxsyycl201003021 [10] 赵忠良, 龙尧松, 余立, 等.高超声速风洞子母弹分离干扰测力试验技术[J].流体力学试验与测量, 2004, 18(3):32-35. http://d.old.wanfangdata.com.cn/Periodical/ltlxsyycl200403007Zhao Z L, Long Y S, Yu L, et al. Hypersonic wind tunnel interference force test of sub-munition reentry separation[J]. Experiments and Measurements in Fluid Mechanics, 2004, 18(3):32-35. http://d.old.wanfangdata.com.cn/Periodical/ltlxsyycl200403007 [11] Resch L R, Hedlund E R, Decesaris C A. Hypersonic shroud separation testing at the naval surface warfare center hyper-velocity wind tunnel 9[R]. AIAA-92-2757, 1992. [12] Resch L, Decesaris C, Hedlund E R. The naval surface warfare center hypervelocity wind tunnel 9 hypersonic shroud separation testing capability[R]. AIAA-92-0676, 1992. [13] Holden M S, Harvey J, MacLean M, et al. Development and application of a new ground test capability to conduct full-scale shroud and stage separation studies at duplicated flight conditions[R]. AIAA-2005-696, 2005. [14] 姜宗林, 李进平, 赵伟, 等.长试验时间爆轰驱动激波风洞技术研究[J].力学学报, 2012, 44(5):824-831. http://d.old.wanfangdata.com.cn/Conference/7714651Jiang Z L, Li J P, Zhao W, et al. Investigation into techniques for extending the test-duration of detonation-driven shock tunnels[J]. Chinese Journal of Theoretical and Applied Mechanics, 2012, 44(5):824-831. http://d.old.wanfangdata.com.cn/Conference/7714651 [15] 恽起麟.风洞实验[M].北京:国防工业出版社, 2000.Yun Q L. Handbook of wind tunnel test[M]. Beijing:National Defense Industry Press, 2000. [16] 李周复.风洞特种实验技术[M].北京:航空工业出版社, 2010.Li Z F. Special experimental techniques in wind tunnels[M]. Beijing:Aviation Industry Press, 2010