Experimental investigation on critical pressure ratio of hypersonic wind tunnel vacuum system
-
摘要: 临界压力是暂冲式高超声速风洞实验段流场破坏时真空罐中的压力值，临界压力比影响Ma10以上大型高超声速风洞真空系统的设计。在Φ0.3m高超声速低密度风洞中进行了Ma10以上喷管的实验，测量了风洞实验段静压、流场的皮托压力、扩压器内表面前后压力、真空罐压力等参数，了解了各部位流场随真空罐压力升高的变化过程，获得了现有风洞Ma10、Ma12和Ma16各自的流场维持所需临界压力比分别为0.34、0.35和0.5。采用FASTRAN软件模拟了风洞流场建立到破坏的非定常过程，计算结果与实验结果较为一致。临界压力比的获得为类似大型高超声速风洞真空系统设计提供了关键基础数据。Abstract: When the pressure in the vacuum container of the intermittent type hypersonic wind tunnel rises up to a certain extent, the flow field in the test section begins to destroied, and the static pressure in the test section would be unstable. The pressure in the vacuum container at the corresponding unstable point is called the critical pressure. The critical pressure would affect the vacuum system design of large-scale hypersonic wind tunnels (Ma ≥ 10). The experiment is carried out in the Φ0.3m hypersonic low density wind tunnel, where the Mach number is over 10. The pressures in the test section, the pitot tube, the diffuser and the vacuum container have been measured. The critical pressure ratio of Ma10, Ma12 and Ma16 is 0.34, 0.35 and 0.5 respectively. The wind tunnel flow field unsteady process from establishment to destruction is simulated by FASTRAN software. The calculation result is in agreement with experimental result. The investigation provides key data for the vacuum system design of similar larger hypersonic wind tunnels.
-
Key words:
- hypersonic /
- wind tunnel /
- vacuum system /
- critical pressure ratio
-
图 5 稳定段总压、皮托压力、实验段环境压力、真空罐压力数据曲线(状态1)
Figure 5. Pressure variation curves of stagnation (p0) and pitot (p02) and test section environment (p1) and vacuum container (pd) (Case 1)
图 6 扩压器前后静压典型变化图(状态3)
Figure 6. Pressure variation curves of diffuser ahead (pk1) and behind (pk2) during the experiment (Case 3)
图 7 实验段环境压力、真空罐压力数据曲线(状态1)
Figure 7. Pressure variation curves of section environment (p1) and vacuum container (pd) (Case 1)
图 8 实验段环境压力、真空罐压力数据曲线(状态2)
Figure 8. Pressure variation curves of section environment (p1) and vacuum container (pd) (Case 2)
图 9 实验段环境压力、真空罐压力数据曲线(状态3)
Figure 9. Pressure variation curves of section environment (p1) and vacuum container (pd) (Case 3)
表 1 临界压力实验和计算结果(单位：Pa)
Table 1. Critical pressure result of experiment and numerical simulation(unit: Pa)
来流状态 临界压力实验结果 临界压力计算结果 状态1 267 303 状态2 2631 2700 状态3 4913 5600 
下载: 导出CSV
-
[1] A.博普, K.L.戈因.高速风洞试验[M].北京:科学出版社, 1980. [2] 徐华舫.空气动力学基础[M].北京:北京航空学院出版社, 1987. [3] 伍荣林, 王振羽.风洞设计原理[M].北京:北京航空学院出版社, 1985. [4] Smelt R, Sivells J C. Design and operation of hypersonic wind tunnels[J]. JAS, 1953. http://adsabs.harvard.edu/abs/2010PhDT.........8N [5] 徐翔, 伍贻兆, 程克明, 等.高超声速风洞气动布局设计[J].南京航空航天大学学报, 2008, 40(2):271-274. http://www.cnki.com.cn/Article/CJFDTOTAL-NJHK200802028.htmXu X, Wu Y Z, Cheng K M, et al. Aerodynamic configuration design of hypersonic wind tunnwls[J]. Journal of Nanjing University of Aeronautics & Astronautics, 2008, 40(2):271-274. http://www.cnki.com.cn/Article/CJFDTOTAL-NJHK200802028.htm [6] 侯峰伟, 吴斌, 齐大伟.高超声速风洞真空保障系统改造[J].真空, 2014, 51(5):326-38. http://www.cnki.com.cn/Article/CJFDTOTAL-ZKZK201405013.htmHou F W, Wu B, Qi D W. Reformation of vacuum system in hypersonic wind tunnel[J]. Vacuum, 2014, 52(5):36-38. http://www.cnki.com.cn/Article/CJFDTOTAL-ZKZK201405013.htm [7] 童华, 孙启志, 张绍武.高超声速风洞扩压器试验研究与分析[J].实验流体力学, 2014, 28(3):78-81. doi: 10.11729/syltlx20120201Tong H, Sun Q Z, Zhang S W. Investigation and analyse on the diffuser of hypersonic wind tunnel[J]. Journal of Experiments in Fluid Mechanics, 2014, 28(3):78-81. doi: 10.11729/syltlx20120201 [8] Nomura S, Sakakibara S, Hozumi K, et al. NAL new hypersonic wind tunnel system[R]. AIAA-93-5006, 1993. [9] Koppenwallner G. Low density facilities[M]. Gottingen, 1995. [10] 佛兰克K, 陆丹, 马伦E.先进高超声速试验设备[M].北京:航空工业出版社, 2015. [11] Anfimov N. Tsniimash capabilities for acrogasdynamical and thermal testing of hypersonic vehicles[R]. AIAA-92-3962, 1992. [12] Bishop R M. New AEDC wind tunnel capabilities[R]. AIAA-2000-0162, 2000. [13] Coblish J J, Spring S, Davenport A H. Recent efforts at AEDC's Von karman facility and hypervelocity wind tunnel 9 to enhace facility compatibility[R]. AIAA-2002-2782, 2002. -
点击查看大图
计量
- 文章访问数: 186
- HTML全文浏览量: 94
- PDF下载量: 17
- 被引次数: 0
